일본잎갈나무재의 수용성추출물 첨가가 표고버섯의 톱밥재배에 미치는 영향

조남석,정홍채,김동훈,이상선,Ohga, Shoji,Leonowicz, A. 한국목재공학회 2004 목재공학 Vol.32 No.1

표고버섯(Lentinula edodes)의 생장이 매우 좋았던 일본잎갈나무재의 수용성 추출물(water-soluble fraction, WSF)을 분리하여 구성당을 분석한 결과, rhamnose 및 mannose는 거의 없고, glucose도 2.2%로 매우 낮았으며, arabinose가 18.3%, galactose가 75.3%로서 가장 많이 함유되어 있었다. 정제된 추출물의 arabinose와 galactose의 함량비는 1 : 3.4였다. 정제된 WSF를 완전메틸화·가수분해·가스크로마토그래피에 의하여 분석한 결과, β-1,3 결합한 D-galactopyranose가 주쇄를 이루며, 이에 galactose의 C6위에 측쇄로서 β-1,6 결합한 D-galactose와, β-1,6 결합한 L-arabinose가 존재하며, 전자는 2-3개의 D-galactopyranose가 결합을 하고 있고, 후자는 L-arabinofuranose가 1-2개 중간의 측쇄구조를 이루고, 말단은 L-arabinopyranose로 구성되어 있었다. PDA배지에 WSF첨가로 표고의 균사 생장이 매우 증진되었으며, 2-4% 첨가수준에서 균사 생장이 최대였고, 첨가량이 더 많으면 균사의 생장이 오히려 감소되었다. 톱밥배지에서도 PDA 배지에서의 결과와 마찬가지로 WSF첨가로 균사 생장이 증진되었으며, 산림 6호 및 Mok-H의 경우 모두 4% 첨가에서 균사의 생장이 최대로 나타났다. 톱밥배지에 WSF 첨가가 버섯생산량을 증가시켰는바, Mok-H의 경우 무첨가에 비해 약 1.3배, 산림 6호의경우 1.2배 증수되었다. 버섯균 세포벽의 주성분인 ergosterol 함량변화를 측정한 결과, WSF첨가로 미첨가에 비하여 ergosterol의 함량이 증가하였으며, 균사가 콜로니를 형성하는 초기단계에서는 낮은 ergosterol함량을 나타냈으나 자실체가 형성되는 시기에 급격히 높아지는 결과를 나타냈다. 따라서 배지내의 ergosterol함량이 자실체형성의 주요 예측수단으로 이용될 수 있을 것으로 판단된다. The water soluble fractions(WSF) from Japanese larch wood were isolated, purified by anion exchange resin and Sephadex gel filtration and identified its chemical structure by means of periodate oxidation and methylation reactions. Its major components are arabinose and galactose (1 : 3.4). Based on the results of periodate oxidation, methylation and gas chromatographic analysis of purified WSF, main chain is composed of β-1.3-glycosidic linkage among D-galactopyranoses, and two different side chains; β -1,6-glycosidic linkage among 2-3 units of D-galactopyranoses and β-1,6-glycosidic linkage between 1-2 units of Dgalactopyranose and L-arabinopyranose. Addition of WSF to culture media of oak mushroom (Lentinulu edodes) accelerated the mycelial growth. In the case of PDA cultures, 2 percent addition of WSF in Sanlim No. 6 strain and 4 percent of WSF in Mok-H strain mostly enhanced the mycelial growth of the mushroom. In the case of sawdust cultures, 4 percent addition of WSF in two strains showed the best mycelial growth. High percentages addition of WSF inhibited mycelial growth of the mushroom. Mushroom production was increased with addition of WSF. By the addition of WSF, ergosterol contents in the media were quite high at the colonized stage and rapidly increased at the fruiting stage. Therefore the ergosterol content could be utilized as an indicator to evaluate the culture maturity for the mushroom fruiting.

탈리그닌한 자기가수분해 시료로부터 준비한 카복시메틸화 시료의 특성

조남석 한국목재공학회 2004 목재공학 Vol.32 No.1

본 연구는 자기가수분해전 처리를 통하여 제조한 반응성이 높은 셀룰로오스(high reactive cellulose, HRC) 기질의 카르복시메틸화(carboxymethylation, CM화) 특성을 알기 위하여 수행되었으며, 비교를 위하여 시판 알파셀룰로오스(commercial n-cellulose, CAC) 및 침엽수 리파이나기계펄프(Refiner mechanical pulp, RMP) 2종의 시료를 사용하였다. HRC는 12시간 당화처리로 70%, 24시간 처리로 90%, 72시간 처리로 99.5%의 높은 당화율을 나타냈다. 아울러 Cellulase 효소활성에 있어서 처리 전후에 측정된 CMCase 및 Avicelase의 효소활성의 큰 변화가 없었다. 이에 대하여 72시간 처리로 CAC는 57%의 당화율을, 리그닌을 많이 포함하는 RMP는 38%의 매우 낮은 당화율을 보였다. CM화시 리그닌함량이 낮은 HRC 및 CAC시료의 CM화가 용이하였고, 1.13-1.15의 높은 치환도를, 리그닌함량이 많은 RMP는 0.85 정도의 낮은 치환도를 나타냈다. 모든 시료에서 알칼리의 농도는 30%, 3시간 처리가 가장 높은 치환도를 보여주었다. CM화물로부터의 수용성부분은 HRC및 CAC에서 98-98.5%, RMP로부터는 31.5%로 매우 낮았다. 비표면적이 낮은 RMP는 보수도가 매우 낮았으며, 비표면적이 높았던 CAC 및 HRC는 435% 및 321%의 매우 높은 보수도 값을 나타냈다. 팽윤도에 있어서는 비표면적과는 무관하게 HRC, RMP 그리고 CAC 순으로 팽윤율이 커졌다. This study was performed to evaluate the characteristics of the carboxymethylated substrate from high reactive autohydrolyzed cellulose (HRC) and those of commercial a-cellulose (CAC) and refiner mechanical pulp (RMP). Saccharification rates of HRC substrate were achieved over 70% with 12 hr hydrolysis, about 90% with 24 hr, and 99.5% with 72 hr. CMCase and avicelase activities of cellulase onozuka were 4.09 ㎛ G/㎎.min and 14.0 ㎛ G/㎎.min, respectively. There were no any significant changes in cellulase activities with this substrate. The saccharification rates of CAC and RMP were very low, 57% and 38% with 72 hr, respectively. Those lignin-zero autohydrolyzed substrates, HRC and CAC, were highly carboxymethylated at the high alkali concentration, near 30%, for 3 hr. reaction, and resulted in l.U-1.15 of D.S., besides 0.85 of D.S. from RMP. Water solubilities of carboxymethylated substrates were increased with an increase of DS., 98-98.5% from HRC and CAC and 31.5% from RMP. RMP which has low specific surface area showed lower water retention values, compared to high values of 435 and 321% from CAC and HRC, respectively. There were no direct relationship between surface area and swelling ratio of the substrates.

퍼지제어를 이용한 카메라가 장착된 이동로봇의 경로제어

조정태,이석원,남부희 강원대학교 산업기술연구소 2000 産業技術硏究 Vol.20 No.B

This paper describes the path planning method in an unknown environment for an autonomous mobile robot equipped with CCD(Charge-Coupled Device) camera. The mobile robot moves along the guideline. The CCD camera is used for the detection of the existence of a guideline. The wavelet transform is used to find the edge of guideline. It is possible for us to do image processing more easily and rapidly by using wavelet transform. We make a fuzzy control rule using image data as an input then determined the position and the navigation of the mobile robot. The center value of guideline is the input of fuzzy logic controller and the steering angle of the mobile robot is the fuzzy controller output. Some actual experiments show that the mobile robot effectively moves to target position by means of the applied fuzzy control.

설포메틸화법에 의한 無公害 傳統韓紙의 제조에 관한 연구

趙南奭,閔斗植,崔泰鎬,李載源 충북대학교 농업과학기술연구소 1993 農業科學硏究 Vol.10 No.2

This study was performed to investigate the pollution-free papermaking characteristics from paper mulberry by sulfomethylation pulping. Bast fibers were pulped by sulfomethylated cooking liquor and by alkali and alkali-peroxied processes for the comparison. Sulfomethylated pulping resulted in the superior pulp with high yield and better quality compared to those of alkali and alkali- peroxide pulps. Since the pulp was so bright, there was almost no need additional bleaching. Polluttant loads of sulfomethylated pulping effluent were very low in terms of pH, turbidity and color compared to those of alkali. Pollution-free effluents was accomplished by simple filtering treatment with pine bark, charred rice hull and sawdust compost. Pine bark was the most effective in reduction rate of pollutants. Key words : Korean traditional paper, Paper mulberry, Alkali-Peroxide, Sulfomethylated pulping, Effluent.

균근성 식용버섯의 인공재배기술

조남석,角田光利,淺輪和孝 한국목재공학회 2002 목재공학 Vol.30 No.2

廢紙 資源을 이용한 酵素的 糖化에 관한 硏究

趙南奭,閔斗植 충북대학교 농업과학기술연구소 1991 農業科學硏究 Vol.9 No.1

Cellulosic biomass is potentially a major source of raw material for chemicals, food, and fuel in the future. There is a variety of waste cellulosic materials to be expected for many useful products. In Korea, approximately 4.03 million tons of paper and paper products are produced annually, and about 39% of those are finally discarded and incinerated. The aim of this study is to investigate the susceptibility of various waste paper resources to enzymatic saccharification with cellulase. Various grades papers, such as writing papers, paper boards and tissues, are tested. Their hydrolysis rates are ranged from 13.6% to 77.9%. Papers essentially consisting of high grade chemical pulps show the excellant hydrolysis rates due to their lower lignin contents. Newsprint shows very low saccharification rate because of its high groundwood including much lignin. Also activity of cellulase enzyme greatly affected to the saccharification. Concerning recycling and reutilization of cellulase enzyme, an improved almost quantitative recycle process of cellulase was discussed.

저급목재의 자기가수분해 전처리에 의한 고순도 셀룰로오스 기질의 제조

조남석,김병로,백기현 한국목재공학회 2002 목재공학 Vol.30 No.4

본 연구는 자기가수분해전처리를 통하여 반응성이 높은 고순도 셀룰로오스기질을 제조하기 위하여 수행되었다. 공시재의 일반 화학조성은 일본잎갈나무와 신갈나무간에 큰 차이가 있음을 알 수 있었다. 추출물함량은 일본잎갈나무가 신갈나무보다 상당량 많았다. 특히 냉·온수 추출물함량은 2.5∼3.5배 많았다. 이러한 추출물함량의 큰 차이는 일본잎갈나무에는 arabinogalactan이 많이 함유되어 있기 때문인 것으로 사료된다. 리그닌함량은 신갈나무가 잎갈나무보다 5% 정도 낮았으며, 그 대신 홀로셀룰로오스 및 펜토산함량이 각각 3% 정도 높은 값으로 나타났다. 22 ㎏/㎠ 수증기압력에서 5∼60분간의 자기가수분해 전처리과정에서 glucose 함량에는 변화가 없었으나, hemicellulose 및 lignin 함량은 급격한 변화를 보였다. 전처리과정에서 가수분해물의 pH는 3까지 저하되었으며, 이러한 경향은 신갈나무 및 일본잎갈나무에서 동일하게 나타났다. Sodium chlorite 및 sulfite 혹은 bisulfite 전처리 후 자기가수분해가 리그닌함량이 낮은 고순도셀룰로오스기질의 제조에 효과적이었다. 특히 자기가수분해처리재를 알칼리 및 산소-알칼리 2단처리함으로서 0∼0.2%의 리그닌함량을 가지는 고순도기질을 제조할 수 있었다. This study was performed to produce the high reactive lignin zero substrates from autohydrolyzed wood resources. In chemical compositions of used raw-materials, there were significant differences between two species, Japanese larch (Larix leptolepis) and oak (Quercus mongolica) woods. Japanese larch contained 2.5 to 3.5 times higher amounts of extractives than oak wood, which is mainly derived from high content of arabinogalactan in Japanese larch wood. Oak wood has 5% lower lignin content and 3% higher holocellulose and pentosans than larch wood. Concerned to changes in wood components during autohydrolysis pretreatment at 22 ㎏/㎠ steaming pressure for 5∼60 min, glucose content was constant during pretreatment, while hemicellulose and lignin were abruptly changed. Hemicellulose fraction was decreased significantly and lignin contents increased because of its condensation reaction with hemicellulose degradation products. The pH of hydrolyzates during pretreatment was decreased, reached upto pH 3 and since then leveled off. In the case of oak wood, same tendency was observed as in Japanese larch. Autohydrolysis followed by sodium chlorite and sulfite or bisulfite pretreatment was very effective in delignification of the substrates. In particular, two-stage delignification of autohydrolyzed woods with alkali and O_2-alkali resulted in very low lignin content substrates, such as 0∼0.2% lignin substrate.

爆碎處理한 소나무재의 酵素的 糖化에 관한 硏究

趙南奭 충북대학교 농업과학기술연구소 1990 農業科學硏究 Vol.8 No.2

Lignocellulosic materials which are the most abundant resources of organic carbon on the earth have the potential of providing for many useful products. As polysaccharides in lignocellulosic materials are encrusted with aromatic lignin molecules and have high crystallinity, these require pretreatment to improve their digestability by cellulolytic enzymes. Though a number of pretreatment methods have been proposed, the autohydrolysis process or steam explosion process is evaluated as a promising method. The steam explosion process breaks down the structure of wood and other lignocellulosics by hydrolyzing the hemicellulose component, cleaving lignin ether linkages and depolymerizing the lignin component, and enhances enzymatic hydrolysis. This study was performed to investigate the effect of various factors, such as treating conditions, moisture contents, particle size, lignin content and crystallinity of steam-exploded substrates, on the enzymatic hydrolysis. Wood chips were steam-exploded at high steaming pressure of 25-40kg/㎢ for 3-9min. This treatment greatly affected the succeptability of substrates on enzymatic hydrolysis. With the increase in steaming pressure and steaming time, the extent of enzymatic hydrolysis decreased. Particle sizes and moisture contents of substrates also were effective to the hydrolysis rate. The extents of hydrolysis were most effective at the conditions of 30kg/㎢, 3 min. treatment, at wet or air-dried state, and 80-100 meshes particle sizes. There was no direct relationship among lignin content, crystallinity of substrates and hydrolysis rate. Keywords : lignocellulosic material, steam-explosion, enzymatic hydrolysis, crystallinity

忠南 錦山郡 西臺山 一帶의 나비目 昆蟲相

남상호,조영호,장석원,박영준,이선영,나선희 대전대학교 기초과학연구소 2002 自然科學 Vol.13 No.2

충청남도 금산군 서대산 일대의 나비목 곤충상을 조사한 결과 22과 344종 1,936개체가 조사되었다. 이중 밤나방과가 102종 589개체, 자나방과가 67종 440개체로 이 2과가 전체의 50%이상을 차지하였다. 자나방과의 두줄가지나방은 1,936 개체중 85개체가 채집되어 4.4%의 가장 높은 우점도를 나타냈다. 월별 우점종은 4월 노랑무늬물결자나방, 5월 별박이세줄나비, 6월 목도리불나방, 7월 청백무늬밤나방, 8월 두줄가지나방, 9월은 털뿔가지나방이 조사되었다. 월별 종다양도는 4월 2.95, 5월 3.37, 6월 4.63, 7월 4.62, 8월 4.23, 9월은 2.97이었으며, 평균 종다양도는 3.80으로 서대산 일대의 나비목 곤충상은 비교적 양호한 편으로 조사되었다. This study was carried out to investigate Lepidopterous insect fauna from Mt. Seodae in Geumsan-gun, Chungnam. The samples were collected from April to September in 2001. Total 1,936 individuals belonging to 344 species, 22 families of Lepidoptera were collected. The sum of individuals belonging to Noctuidae and Geometridae exceed 50% of the collected samples in that Noctuidae was consisted of 102 species 589 individuals and Geometridae was 67 species 440 individuals. The dominant species in surveyed area was Rikiosatoa grisea of Geometridae, the dominant species by month were Idiotephria amelia in April, Neptis pryeri in May, Paraona staudinger in June, Ercheia niveostrigata in July, Rikiosatoa grisea in August and Alcis angulifera in September respectively. Species diversity indices by month were 2.93 in April, 3.37 in May, 4.63 in June, 4.62 in July, 4.23 in August and 2.97 in September respectively. Mean species diversity index was 3.80.

외측 미칩 갑상선에서 발생하여 다발성 전이로 발현된 유두상 갑상선암 1예

천남일,이창훈,홍세인,정진욱,윤인석,조동혁,강호철,정동진,정민영 대한내분비학회 2001 Endocrinology and metabolism Vol.16 No.4-5