http://chineseinput.net/에서 pinyin(병음)방식으로 중국어를 변환할 수 있습니다.
변환된 중국어를 복사하여 사용하시면 됩니다.
제올라이트 분말도와 치환율에 따른 시멘트모르타르의 활성도 지수 평가에 관한 실험적 연구
윤창복 ( Yoon Chang Bok ),박장현 ( Park Jang Hyun ),이한승 ( Lee Han Seung ) 한국구조물진단유지관리공학회 2019 한국구조물진단유지관리공학회 학술발표대회 논문집 Vol.23 No.1
This research and development analysis provides numerical analysis techniques that can be used conveniently to determining the safety of the current state and to predict the stability in the future. It also seeks to present algorithms of back analysis to develop unified management system for control, prediction, coordination, and information modeling that can reasonably handle appropriate responses to structural behavior at project sites and design changes.
알칼리 자극제가 지오폴리머 페이스트의 압축강도와 탄산화 특성에 미치는 영향에 관한 연구
윤창복 ( Yoon Chang-bok ),박장현 ( Park Jang-hyun ) 한국건축시공학회 2022 한국건축시공학회 학술발표대회 논문집 Vol.22 No.2
In this study, the compressive strength and carbonation properties of geopolymer paste according to the amount of alkali admixture added were evaluated for the development of geopolymer concrete that recycles industrial waste. A geopolymer paste specimen was prepared using Ca(OH)2 as an admixture, and the prepared specimen was standard cured for 28 days. After curing, the compressive strength of the specimen was measured. As the amount of alkali admixture increased, the compressive strength increased. After curing, carbonation was carried out for 7 days in a CO2 5% environment. As a result of comparative evaluation of the amount of CaCO3 produced according to carbonation, the amount of CaCO3 produced increased as the amount of Ca(OH)2 added increased. However, when the amount of admixture added exceeds 5%, the increase rate decreases, so the optimum addition rate is considered to be 5%.
시멘트 모르타르 내 실란-실록산 고정을 위한 다공성 혼화재료의 활용성 평가
윤창복 ( Yoon Chang-bok ) 한국건축시공학회 2023 한국건축시공학회 학술발표대회 논문집 Vol.23 No.1
After mixing the pozzolan-based powder and water repellent with porosity into the cement mortar, microanalysis and measurement of the water repellent contact angle confirmed that the NZS specimen using natural zeolite had the highest contact angle. The specific surface area is increased due to the porosity of natural zeolite, so the adhesion of silane-siloxane is relatively better than that of FA, and it is judged to have a uniform distribution inside the mortar.
철근 콘크리트의 혼화재와 물시멘트비에 따른 철근의 임피던스에 관한 실험적 연구
박장현 ( Park Jang-hyun ),윤창복 ( Yoon Chang-bok ),이한승 ( Lee Han-seung ) 한국구조물진단유지관리공학회 2019 한국구조물진단유지관리공학회 학술발표대회 논문집 Vol.23 No.1
In this study, the impedance of reinforced concrete embedded in concrete was measured and compared with W/B and admixture replacement ratio. As a result, the impedance of rebars increased in all frequency sections with increasing blast furnace slag replacement amount of cement in all W/B Respectively. It is considered that the electro resistance in the concrete increases due to the potential hydraulic properties of the blast furnace slag, and thus the polarization resistance also increases.
포졸란계 천연재료 및 발수재료를 활용한 발수모르타르 개발을 위한 실험적 연구
박장현 ( Park Jang-hyun ),윤창복 ( Yoon Chang-bok ) 한국구조물진단유지관리공학회 2021 한국구조물진단유지관리공학회 학술발표대회 논문집 Vol.25 No.2
수분의 침투로 인한 콘크리트 열화를 방지하고자 포졸란계 천연재료와 발수성을 갖는 재료인 PDMS, 칼슘스테아레이트를 활용하여 모르타르를 제작하였다. 포졸란계 천연제료인 제올라이트와 유성발수제를 결함합 ZW의 분체를 혼입한 시멘트 모르타르 시험체가 칼슘스테아레이트를 결합한 ZC에 비해 압축강도 및 발수접촉각이 우수한 성능을 나타내는 것을 확인하였으며, 기준모르타르에 대비하여 저하되는 압축강도를 보완하기 위한 추가 연구가 필요할 것으로 판단된다.
유/무기 복합 발수제를 혼입한 모르타르의 재료특성 평가
김완수 ( Wan-su Kim ),윤창복 ( Chang-bok Yoon ),조인성 ( In-sung Cho ),이한승 ( Han-seung Lee ) 한국구조물진단유지관리공학회 2020 한국구조물진단유지관리공학회 논문집 Vol.24 No.6
발수제를 콘크리트 표면에 함침시키는 방법은 콘크리트의 균열이 발생할 경우, 기대하는 내구성을 확보할 수가 없다. 최근, 다양한 방수 및 발수 재료들을 콘크리트나 모르타르 내부에 혼입하여 균열 내부에서도 발수성을 확보하였으나 압축강도가 크게 저하되었다. 압축강도 저하를 극복하기 위해 아직까지 유기물과 무기물의 장점들을 동시에 이용한 연구가 없기 때문에, 본 연구에서는 유기물과 무기물을 적절히 혼합한 유무기 복합 발수제를 모르타르에 혼입하여 물리적 특성 및 발수성능을 평가하였다. 유무기 복합 발수제 혼입 시 Liquid 시험체에 비해 플로우 약 10%, 공기량이 약 50% 감소하였으며, P6L1 시험체의 경우, 기존 발수제인 Powder와 같은 39.5MPa로 무혼입 모르타르 대비 약 3.5%의 압축강도 저하를 확인하였다. 발수성능도 유무기 복합 발수제 혼입 시험체가 기존의 발수제 혼입 시험체인 Powder보다 높은 발수성을 확인하였으며, 염화물 침투 저항성 평가결과, 유무기 복합 발수제 혼입 시험체가 무혼입 모르타르 대비 약 45% 통과 전하량이 감소되는 것을 확인하였다. 이상의 실험을 종합하면, Powder 발수제와 Liquid 발수제를 5:1의 비율로 혼입한 P5L1 유무기 복합 발수제가 압축강도 저하 방지 및 발수성능 확보를 위하여 가장 합리적이라고 판단된다. When the concrete surface layer is damaged, The method of impregnating the concrete surface with a water repellent cannot secure the expected durability. Recently, various waterproofing and water-repellent materials were mixed into concrete or mortar to secure water repellency even inside cracks, but compressive strength was greatly reduced. In order to overcome the decrease in compressive strength, there has not yet been a study using the merits of organic and inorganic materials at the same time, so in this study, the physical properties and water repellency performance were evaluated by mixing an organic/inorganic composite water repellent appropriately mixed with an organic and inorganic material into the mortar. When mixed with organic/inorganic water repellent, the flow and air content were reduced by about 10% and 50% compared to the Liquid specimen. In the case of the P6L1 specimen, it was confirmed that the compressive strength decreased by about 3.5% compared to the non-mixed mortar at 39.5 MPa, the same as the existing water repellent, Powder. Water-repellent performance The organic-inorganic composite water repellent mixture specimen confirmed higher water repellency than the existing water repellent mixture powder, and the chloride penetration resistance evaluation result showed that the organic-inorganic composite water repellent mixture specimen reduced the passing charge by about 45% compared to the non-mixed mortar. In summary, it is judged that the P5L1 organic/inorganic composite water repellent mixed with a powder water repellent and a liquid water repellent in a ratio of 5:1 is the most reasonable to prevent the decrease in compressive strength and secure water repellency.
무기물 금속염계 발수분체를 혼입한 시멘트 모르타르의 물리적 특성 및 수분흡수저항성에 대한 실험적 연구
이원근(Won Geun Lee),윤창복(Chang Bok Yoon) 한국건설순환자원학회 2021 한국건설순환자원학회 논문집 Vol.9 No.4
본 연구에서는 금속염계 무기물인 발수분말과 포졸란계 재료인 천연제올라이트 분말을 사용하여 시멘트 모르타르에 혼입하고 물리적 특성 및 수분에 대한 저항성을 확인하였다. 무기물 금속염계 발수분말을 단독으로 혼입한 시험체에 비해서 천연제올라이트를 동시에 사용한 시험체에서 수분침투실험 및 그에 수반하는 염화물 침투시험에서 높은 저항성을 갖는 것을 확인 할 수 있었다. 금속염계 발수분말을 사용하는 경우 불용성으로 인하여 수분침투저항성이 내부에서 고르게 분산되지 못하고 표면에 국한되었으며 천연제올라이트와 동시에 사용하는 경우 포졸란 반응으로 인해 수화초기의 응결시간이 빠르고 또한 천연제올라이트의 다공성 내부에 발수분말이 부착되어 내부에서도 수분저항성이 일부 생성된 것으로 판단된다. In this experimental, water-repellent powder, which is a metal salt-based inorganic substance, and natural zeolite powder, which is a pozzolan-based material, were mixed into cement mortar, and their physical properties and resistance to moisture were confirmed. It was confirmed that the test specimen using natural zeolite at the same time had excellent resistance in the water permeation test and the chloride penetration test as compared with the test specimen in which the inorganic metal salt-based water-repellent powder was mixed alone. When a metal salt-based water-repellent powder is used, it cannot be uniformly dispersed inside water due to its insoluble property, and is limited to the surface. When used at the same time as natural zeolite, the setting time at the initial stage of hydration is fast due to the pozzolan reaction, and the water-repellent powder adheres to the porous of the natural zeolite and is evenly distributed inside the test specimen to generate some water resistance.