http://chineseinput.net/에서 pinyin(병음)방식으로 중국어를 변환할 수 있습니다.
변환된 중국어를 복사하여 사용하시면 됩니다.
다중 회전 날개 및 가이드 판 설치 파쇄장치를 통해 제작된 순환골재가 콘크리트의 역학적 특성 및 탄산화 저항성에 미치는 영향
조성광(Sung-Kwang Cho),김규용(Gyu-Yong Kim),유하민(Ha-Min Eu),김용래(Yong-Rae Kim),이철민(Chul-Min Lee) 한국건설순환자원학회 2021 한국건설순환자원학회 논문집 Vol.9 No.2
본 연구에서는 기존의 낮은 순환골재 품질을 개선하기 위해 다중 회전 날개 및 가이드 판을 순환골재 파쇄장치에 설치하였다. 신기술의 파쇄 효율을 평가하기 위해 시뮬레이션 분석을 실시한 결과, 가이드판을 설치함에 따라 파쇄 드럼 내부에서 대부분의 투입물이 파쇄되고, 다중 회전 날개 및 가이드판이 파쇄물의 상승 회류를 유도하기 때문에 파쇄 효율이 높은 것으로 나타났다. 이를 통하여, 다중 회전 날개와 가이드 판을 적용한 파쇄장치는 기존 순환골재 파쇄장치보다 파쇄효율 및 경제성이 우수한 것으로 확인되었다. 또한, 신기술로 생산한 순환골재는 기존 순환골재에 비해 골재 표면에 부착된 시멘트 페이스트 및 모르타르의 양이 적었으며, 이를 혼입한 콘크리트에서 역학적 성능 및 탄성계수 저하 현상이 감소하는 것으로 확인되었다. 하지만, 신기술로 생산한 순환골재는 표면에 남아있는 미세 시멘트 페이스트 및 모르타르로 인해 콘크리트의 탄산화 저항성이 천연골재 수준으로 개선되지는 못하였다. 따라서, 순환골재를 혼입한 콘크리트의 내구성 저하 현상을 개선하기 위한 장치 개선 또는 결합재 개발 등의 추가 연구 및 실험이 필요하다고 판단된다. In this work, multi-turn wings and guide plates are installed on recycled aggregate crushing devices to improve existing low recycled aggregate quality. Simulation analysis to evaluate the crushing efficiency of the new device shows enhanced crushing efficiency since the installation of guide plates shreds most of the inputs inside the crushing drum, and the multi-turn wings and guide plates induce rebound and circulation of the aggregate. Through this, the new device was found to be more economical and efficient than the existing recycled aggregate crushing device. Also, the amount of cement paste and mortar attached to the surface of the aggregate was smaller than that of the existing recycled aggregate, and it was found that the mechanical properties and elastic modulus deterioration were reduced. However, the carbonation resistance of concrete was not improved to the level of natural aggregates due to the remaining tiny cement paste and mortar on the surface of the new recycled aggregate. Therefore, it is deemed necessary to further research and experiment such as device improvement or binder development to reduce durability degradation of concrete mixed with new recycled aggregate.
고로슬래그미분말 사용율을 높인 콘크리트의 시공성 및 공학적 특성에 관한 실험적 연구
조성광(Sung-Kwang Cho) 융복합지식학회 2013 융복합지식학회논문지 Vol.1 No.1
콘크리트의 고품질화에 대한 요구 및 경제성 문제 해결을 위해 고로슬래그미분말을 콘크리트용 혼화재로 활용하고 있다. 고로슬래그미분말의 활용을 통해 콘크리트는 우수한 성능이 발현되고, 환경 오염을 방지 할 수 있으며, 경제적인 장점을 얻을 수 있다. 그러나 고로슬래그는 건설 현장에서 콘크리트 강도 발현이 지연되는 등을 단점을 많이 가지고 있어, 고로슬래그미분말을 시멘트 대체재로 활용한 콘크리트의 특성에 관한 검토가 필요하다. 본 연구는 산업부산물인 고로슬래그미분말을 대량 활용한 콘크리트의 물결합재비, 고로슬래그미분말 치환율 및 분말도에 따른 시공성, 응결특성, 공학적 특성 및 내구특성을 실험ㆍ실증적으로 비교ㆍ검토함으로서 콘크리트용 혼화재로서 고로슬래그미분말의 활용 및 품질관리를 위한 기초자료를 제시하는데 목적이 있다. As a part of efforts for conformity of demand to high quality of concrete and solution of economic problem, ground granulated blast furnace slag has been utilization of ground granulated blast furnace slag, superior performance can be ensured, environmental pollution can be prevented and economical advantage can be obtained. But ground granulated blast furnace slag has a lot of disadvantages like retardation of strength manifestation……etc in the construction field, so properties examination of concrete using ground granulated blast furnace slag instead of cement is necessary. For upper necessity, it is planed that basic data for utilization and performance management of ground granulated blast-furnace slag by means of cement replacement is presented with experimental comparison and investigation of workability and engineering properties of concrete according to the replacement ration and fineness of blast-furnace slag.
Guide-Vane의 형태에 따른 멀티 사이클론의 압력손실 변화
박형용(Hyeong-Yong Park),조성광(Sung-Kwang Cho),설승윤(Seoung-Yun Seol) 대한기계학회 2015 대한기계학회 춘추학술대회 Vol.2015 No.11
Cyclone is the one of the dust-separating mechanism that using centrifugal force. Performance of the cyclone is indicated by pressure loss and collection efficiency. Sometimes, Multi-cyclone is used to improve the collection efficiency in limited area. In this case, install the guide-vane in the 1st cyclone’s vortex finder in order to reduce the additional pressure loss. In this study, we have found that the shape of guide vane can affect the reduction effect of multi cyclone’s pressure loss. And this effect can be varied by the diameter and length of vortex finder and the flow direction between 1st cyclone and 2nd cyclones.