An experimental study on characteristics of two-phase flows in vertical pipe

심우건,B. M. Bae,N. W. Mureithi 대한기계학회 2010 JOURNAL OF MECHANICAL SCIENCE AND TECHNOLOGY Vol.24 No.10

The characteristics of two-phase flow in a vertical pipe are investigated to provide information for understanding the excitation mechanisms of flow-induced vibration. An analytical model for two-phase flow in a pipe was developed by Sim et al. (2005), based on a power law for the distributions of flow parameters across the pipe diameter, such as gas velocity, liquid velocity and void fraction. An experimental study was undertaken to verify the model. The unsteady momentum flux impinging on a ‘turning tee’ (or a ‘circular plate’) has been measured at the exit of the pipe, using a force sensor. From the measured data, especially for slug flow, the predominant frequency and the RMS value of the unsteady momentum flux have been evaluated. It is found that the analytical method, given by Sim et al. for slug flow, can be used to predict the momentum flux.

편심환내의 비선형 회전 유동

심우건,Sim, U-Geon 대한기계학회 2000 大韓機械學會論文集A Vol.24 No.1

The steady rotating flows in eccentric annulus has been studied by a numerical method based on the spectral collocation method. The inner cylinder has a constant angular velocity while the outer on e is stationary. Flow between eccentric cylinders is of considerable technical importance as it occurs in journal bearings. In the present work, the governing equations for laminar flow are expressed as Navier-Stokes equations, including the non-linear convection terms. The solutions were utilized i, estimate the effects of the nonlinear terms on the load acting on the rotating cylinder. Based on the half and the full Sommerfeld methods, the load on the rotating cylinder is evaluated with eccentricity, by integrating the pressure and skin friction around the cylinder. The attitude angle and Sommerfeld reciprocal are calculated from the load. Also, the torque on the rotating inner cylinder was calculated. considering the skin friction. The attitude angle and Sommerfeld reciprocal are decreased with eccentricity. Viscous damping coefficient due to the skin friction becomes larger with decreasing the annular space. It is found the non-linear effects of the convection terms on the flow and the load are important. especially on the attitude angle, for relatively wide annular configurations however, the effects on those are minor for very narrow annular ones.

Stratified Steady and Unsteady Two-Phase Flows Between Two Parallel Plates

심우건 대한기계학회 2006 JOURNAL OF MECHANICAL SCIENCE AND TECHNOLOGY Vol.20 No.1

동심원내에서 진동하는 내부 실린더에 작용하는 유체유발력의 근사적 해법

심우건 한국소음진동공학회 1997 소음 진동 Vol.7 No.5

An approximate analytical method has been developed for estimating hydrodynamic forces acting on oscillating inner cylinder in concentric annulus. When the rigid inner cylinder executes translational oscillation, fluid inertia and damping forces on the oscillating cylinder are generated by unsteady pressure and viscous skin friction. Considering the dynamic-characteristics of unsteady viscous flow and the added mass coefficient of inviscid fluid, these hydrodynamic forces including viscous effect are dramatically simplified and expressed in terms of oscillatory Reynolds number and the geometry of annular configuration. Thus, the viscous effect on the forces can be estimated very easily compared to an existing theory. The forces are calculated by two models developed for relatively high and low oscillatory Reynolds numbers. The model for low oscillatory Reynolds number is suitable for relatively high ratio of the penetration depth to annular space while the model for high oscillatory Reynolds number is applicable to the case of relatively low ratio. It is found that the transient ratio between two models is approximately 0.2~0.25 and the forcea are expressed in terms of oscillatory Reynolds number, explicity. The present results show good agreements with an existing numerical results, especially for high and low penetration ratios to annular gap.

동심환내에서 회전하는 실린더에 작용하는 유체동하중

심우건 한국소음진동공학회 2001 소음 진동 Vol.11 No.3

The rotating inner cylinder executes a periodic translational motion in concentric annulus while the outer one is stationary. In the study of flow-induced vibrations and relaxed instabilities, it is of interest to evaluate the fluid-dynamic forces acting on the rotating inner cylinder. In the present work, the governing equations for the confined flow are expressed as Navier-Stokes equations, including the steady and unsteady terms. The fluid parameters for steady flow generated by the rotating cylinder are determined analytically while the unsteady ones by the oscillatory motion are evaluates by a numerical method based on the spectral collocation method. In order to validate the numerical approach, the numerical results are compared wish the analytical ones given by existing theories, for simple cases where the both approaches are applicable. Good agreement was found between the results. It is found the effects of the Reynolds number, defined by rotating velocity, on the fluid-dynamic forces are important for the case of relatively low oscillatory Reynolds number, defined by oscillatory frequency : j.e., in case of $Re_\omega\gg Re_S$.

진동하는 외부 실린더에 의해 유발되는 비정상 압력의 실험적 고찰

심우건 대한기계학회 1995 대한기계학회논문집 Vol.19 No.2

Experiments have been performed to test the analytical tools developed concurrently for the motion-related unsteady pressure in annular passages. The outer cylindrical body was oscillated by a shaker in either rocking motion about a hinge-point or lateral translation motion. In the equilibrium configuration the two bodies are either concentric or eccentric, in the plane of oscillation or normal to it. The unsteady pressure generated by the oscillatory motion with low amplitudes (displacement/radius) was measured on wall of the fixed inner cylinder at various axial and azimuthal locations. The unsteady pressure were compared with theoretical predictions, and agreement was found to be within 10%. Experiments have been shown that the effect of flow velocity on the unsteady pressure is minimal and the pressure increases more or less with oscillatory motion, for low flow velocities (Re = 2 900).

편심환내의 회전 유동

심우건 한국공작기계학회 1997 한국생산제조학회지 Vol.6 No.3

A numerical method based on the spectral collocation method is developed for the steady rotating flows in eccentric annulus. Steady flows between rotating cylinders are of interest on lubrication in large rotating machinery. Steady rotating flow is generated by the rotating inner cylinder with constant angular velocity. The governing equations for laminar flow are simplified from Navier-Stokes equations by neglecting the non-linear convection terms. Integrating the pressure round the rotating cylinder based on the half Sommerfeld method, the load on the cylinder is evaluated with eccentricity. The attitude angle and Sommerfeld variable are calculated from the load. It is found that those values are influenced by the eccentricity. The attitude and Sommerfeld reciprocal are decreased with eccentricity. As expected, the effect of the annular gap ration on them is negligible.

Parametric study of two-phase flow by integral analysis based on power law distribution

심우건,N. W. Mureithi,M. J. Pettigrew 대한기계학회 2010 JOURNAL OF MECHANICAL SCIENCE AND TECHNOLOGY Vol.24 No.7

To understand the fluid dynamic forces acting on a structure subjected to two-phase flow, it is essential to obtain detail information on the characteristics of that flow. The distributions of flow parameters across a pipe, such as gas velocity, liquid velocity and void fraction,may be assumed to follow a power law (Cheng 1998; Serizawa et al. 1975). The void fraction profile is, for example, uniform for bubbly flow, whereas for slug flow it is more or less parabolic. In the present work, the average values of momentum flux, slip ratio and other parameters were derived by integral analysis, based on approximate power law distributions. A parametric study with various distributions was performed. The existing empirical formulations for average void fraction, proposed by Wallis (1969), Zuber et al. (1967) and Ishii (1976), were considered in the derivation of the present results. Notably, the unsteady momentum flux for slug flow was approximated.

동심환내에서 회전하는 실린더에 작용하는 유체동하중

심우건 한국소음진동공학회 2001 한국소음진동공학회 논문집 Vol.11 No.3

The rotating inner cylinder executes a periodic translational motion in concentric annulus while the outer one is stationary. In the study of flow-induced vibrations and related instabilities, it is of interest to evaluate the fluid-dynamic forces acting on the rotating inner cylinder. In the present work, the governing equations for the confined flow are expressed as Navier-Stokes equations, including the steady and unsteady terms. The fluid parameters for steady flow generated by the rotating cylinder are determined analytically while the unsteady ones by the oscillatory motion are evaluated by a numerical method based on the spectral collocation method. In order to validate the numerical approach, the numerical results are compared with the analytical ones given by existing theories, for simple cases where the both approaches are applicable. Good agreement was found between the results. It is found the effects of the Reynolds number, defined by rotating velocity, on the fluid-dynamic forces are important for the case of relatively low oscillatory Reynolds number, defined by oscillatory frequency: i.e., in case of Re_w >> Re_s

환상류에 의한 유연성 실린더의 안정성 분석 ( Dynamic Stability of a Flexible Cylinder Subjected to Annular Flow )

심우건,배윤영,이중섭 대한기계학회 1993 대한기계학회 춘추학술대회 Vol.- No.-